Outdoor Charcoal Barbecue Grill Model No. CBT806 Series
WThis grill is for outdoor use only, and shall not be used in a building,
garage or any other enclosed area.
W For residential use only. This grill is NOT for commercial use.
WNever use charcoal that has been pre-treated with lighter fluid. Use only
a high grade plain charcoal, charcoal/wood mixture, lump charcoal or
cooking wood. The conversion to or attempted use of any other fuel
source in this charcoal grill is dangerous and will void your warranty
WThis grill is not intended for and should never be used as a heater. TOXIC
fumes can accumulate and cause asphyxiation.
WDo not use grill for indoor cooking. Toxic carbon monoxide fumes can
accumulate and cause asphyxiation.
WThis grill is safety certified for use in the United States and Canada only.
Do not modify for use in any other location. Modification will result in a
safety hazard and will void the warranty.
WDo NOT operate, light or use this appliance within ten (10) feet (3.05 m)
of walls, structures or buildings.
WApartment Dwellers: Check with management to learn the requirements
and fire codes for using a charcoal grill in your apartment complex. If
allowed, use outside on the ground floor with a ten (10) foot (3.05 m)
clearance from any structure. Do not use on or under balconies.
WMinimum clearance from sides and back of unit to combustible
construction is 36 inches (91.4 cm). Do not use this appliance under any
type of overhang or roof.
WDo not use gasoline, kerosene or alcohol for lighting.
WDo not use in an explosive atmosphere. Keep grill area free and clear
from combustible materials, gasoline and other flammable vapors and
WDo not store or use gasoline or other flammable liquids or vapors within
25 feet (7.62 m) of this appliance.
WDo not alter grill in any manner. Any altering will void your warranty.
WDo not use the grill unless it is COMPLETELY assembled and all parts are
securely fastened and tightened.
WThis grill should be thoroughly cleaned and inspected on a regular
WUse only Blue Rhino Global Sourcing, Inc. factory authorized parts. The
use of any part that is not factory authorized can be dangerous and will
void your warranty.
WDo not use this appliance without reading “Operating Instructions” in
WDo not touch metal parts of grill until it has completely cooled (about
45 min.) to avoid burns, unless you are wearing protective gear (pot
holders, gloves, BBQ mittens, etc.).
WNever touch grates (charcoal or cooking), ashes or coals to see if they
WDo not use on wooden decks, wooden furniture or other combustible
WDo not use in or on boats or recreational vehicles.
W Position grill so wind cannot carry ashes to combustible surfaces.
WDo not use in high winds.
W Never lean over the grill when lighting.
WDo not leave a lit grill unattended. Keep children and pets away from
grill at all times.
WDo not attempt to move grill when in use. Allow the grill to cool (about
45 min.) before moving or storing.
WWhen cooking, fire extinguishing materials shall be readily accessible.
In the event of an oil/grease fire, do not attempt to extinguish with
water. Use type BC dry chemical fire extinguisher or smother with dirt,
sand or baking soda.
WAlways open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
WIf grill has not been cleaned, a grease fire can occur that may damage
WDo not place empty cooking vessels on the appliance while in operation.
WUse caution when placing anything on the grill while the appliance is in
WNever add lighting fluid to hot or even warm coals as flashback may
occur causing serious injury or damage to property.
WAlways place your grill on a hard, non-combustible level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
WDo not remove the ashes until they are completely and fully
WLive hot briquettes and coals can create a fire hazard.
W Always empty the bottom bowl and grill after each use.
WDo not place fuel (charcoal briquettes, wood or lump charcoal) directly
into bottom of grill. Place fuel only on the charcoal pan/grid.
WDo not allow charcoal to rest on the walls of grill. Doing so will greatly
reduce the life of the metal and finish of your grill.
WCheck to make sure the air vents are free of debris and ash before using
WExtinguished coals and ashes should be placed a safe distance from all
structures and combustible materials.
W With a garden hose, completely wet the surface beneath and around
grill to extinguish any ashes, coals or embers which may have fallen
during the cooking or cleaning process.
WAlways wear protective gloves when adding fuel (charcoal briquettes,
wood or lump charcoal) to retain desired heat level.
WKeep all electrical cords away from a hot grill.
WAlways use a meat thermometer to ensure food is cooked to a safe
WNever cover entire cooking area with aluminum foil.
WUse protective gloves when assembling this product.
WDo not force parts together as this can result in personal injury or
damage to the product.
WDeath, serious injury or damage to property may occur if the above is
not followed exactly.
WDANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage